Email Address

[email protected]

Phone Number

+0086-371-86162511

Muscovite Flotation Test

Get In Touch

muscovite flotation test

In each flotation test, 2 g of a muscovite. Minerals | Free Full-Text | Effect of Chain Length Compatibility of Alcohols on ... A portion of dodecyl amine (DDA) in a muscovite flotation system was replaced with alcohols with different carbon-chain ... Reagents were added at certain concentrations to the beaker in accordance with the test requirement. Study on Flotation Separation of Muscovite ...

Get Quote

An investigation into the flotation of muscovite with an ...

27/07/2015· Electroacoustic zeta potential measurements and single mineral flotation tests were used to determine the effect of Custamine 8113 (collector) and Norlig-H (depressant) on muscovite. These results were then compared to those of gangue minerals (feldspar and quartz). Muscovite showed an isoelectric point (IEP) at pH 3.5. Feldspar and quartz did not have an IEP, having negative zeta …

Get Quote

muscovite flotation test - ah-betriebswirtschaft.de

muscovite flotation test. Electroacoustic zeta potential measurements and single mineral flotation tests were used to determine the effect of Custamine 8113 collector and NorligH depressant on muscovite These results were then compared to those of gangue minerals feldspar and quartz Muscovite As a leading global manufacturer of crushing equipment, milling equipment,dressing …

Get Quote

muscovite flotation test - ME Mining Machinery

muscovite flotation test. 27/07/2015· Pure mineral flotation experiments were conducted on both muscovite and quartz (the feldspar as provided was too fine for flotation to be effective). All flotation tests were carried out in a 1.5 L Denver flotation cell at an airflow rate of 4.5 L/min with concentrate collected after 30 s, 60 s and 300 s. The frother Cp-102a was added as needed to create ...

Get Quote

Flotation Properties of Muscovite - mdpi.com

03/06/2016· Muscovite (50 g) was roasted for an hour at 200, 400, 600, 800 and 1000 C in a muffle furnace with a heating rate of 8 C/min. Micro-flotation experiments of roasted muscovite (2 g) were conducted using a XFG5-35 flotation machine (Wuhan Rock Crush and Grand Equipment Manufacture Co., Wuhan, China) with a spindle speed of 2000 r/min. The reagents were added in the following …

Get Quote

An investigation into the flotation of muscovite with an ...

Electroacoustic zeta potential measurements and single mineral flotation tests were used to determine the effect of Custamine 8113 (collector) and Norlig-H (depressant) on muscovite. These results were then compared to those of gangue minerals (feldspar and quartz). Muscovite showed an isoelectric point (IEP) at pH 3.5. Feldspar and quartz did not have an IEP, having negative zeta potentials over the pH …

Get Quote

muscovite flotation test - aviator-budziak.pl

06/09/2016· muscovite flotation test. Authors Edward SiameAbout Roasting Leaching froth flotation process for separation mica technology . Flotation is a process of separation and concentration based on differences in the . Of the flotation techniques, froth flotation is the only technique that has .. for base metal sulfides, long chain amines for quartz, mica,. Depression effect of corn starch on ...

Get Quote

Study on Flotation Separation of Muscovite and Kaolinite ...

The condition which can efficiently separate the muscovite and kaolinite was found out: 5×10-5 mol·L-1 ~1×10-4 mol·L-1 1431 as collector and pH=5.The feasibility of flotation separation in this condition was validated by artificial mixed minerals separation test. The results of zeta potential measurement, infrared spectrum analysis and adsorption quantity test show that 1431 was adsorbed on the surface on muscovite …

Get Quote

Flotation and adsorption of muscovite using mixed cationic ...

Besides dynamic contact angle analysis, AFM and flotation tests were carried out to gain detail information about the wettability of muscovite, adhesion ability of bubbles towards muscovite ...

Get Quote

muscovite flotation test - aviator-budziak.pl

06/09/2016· muscovite flotation test. Authors Edward SiameAbout Roasting Leaching froth flotation process for separation mica technology . Flotation is a process of separation and concentration based on differences in the . Of the flotation techniques, froth flotation is the only technique that has .. for base metal sulfides, long chain amines for quartz, mica,. Depression effect of corn starch on ...

Get Quote

Study on Flotation Separation of Muscovite and Kaolinite ...

The condition which can efficiently separate the muscovite and kaolinite was found out: 5×10-5mol·L-1~1×10-4mol·L-11431 as collector and pH=5.The feasibility of flotation separation in this condition was validated by artificial mixed minerals separation test. The results of zeta potential measurement, infrared spectrum analysis and adsorption quantity test show that 1431 was adsorbed on ...

Get Quote

[PDF] Flotation and adsorption of mixed cationic/anionic ...

Abstract The adsorption of dodecylamine acetate (DAA), sodium oleate (NaOL) and DAA–NaOL mixtures on muscovite mica were investigated through flotation tests, zeta potential measurements, and pyrene fluorescence tests. The results show that the muscovite mica has a negative charge over the pH range 2–12. The muscovite mica did not float in the presence of NaOL alone.

Get Quote

Understanding the effect of mineralogy on muscovite ...

Electroacoustic zeta potential measurements and single mineral flotation tests were used to determine the effect of Custamine 8113 (collector) and Norlig-H (depressant) on muscovite. These results ...

Get Quote

2015-Flotation and adsorption of muscovite using mixed ...

AbstractThe performance of the mixed dodecylamine chloride (DDA)/octanol (OCT) surfactants on muscovite flotation was investigated using flotation tests, and their adsorption mechanisms on muscovite and air/water interface were clarified using contact angle measurement, surface tension and molecular dynamics (MD) simulations. The flotation results indicate that the recovery of muscovite r...

Get Quote

Mechanism of separating muscovite and quartz by flotation

investigate the flotation of muscovite and quartz [14−18]. General, muscovite can be recovered using cationic collectors, such as amines. Unfortunately, few of them investigated only one kind of amine. Because of the differences in length of carbon chain and constitute of polar head, amines perform different collector ability and selectivity to muscovite and quartz. There is a wide knowledge ...

Get Quote

DEPRESSION EFFECT OF CORN STARCH ON MUSCOVITE MICA AT ...

A series of flotation tests were performed in a 30 cm3 XFG hitch groove type flotation machine with the stirring rate of 1960 rpm. For each test, 2 g sample was added into the flotation cell, and then filled with the solution which pH had been adjusted by sulfuric acid. After stirring 3 min, a certain amount of corn starch solution was added into as the inhibitor of muscovite mica, and then ...

Get Quote

The reclamation of mica flakes from tailing disposal using ...

minerals are muscovite, lepidolite, phlogopite, biotite, and lepidomelane which among them, ... The best conditions of the flotation tests are listed in Table 2. Mica flotation was carried out using various collectors in different pH. Oleic acid and Flotinor FS-2 as fatty acid anionic collectors, and relatively short chain amine cationic collectors like Flotigam EDA and hexadecylamin, and long ...

Get Quote

Flotation Behavior of Complex Sulfide Ores in the Presence ...

2.4. Batch Flotation Tests. Flotation tests were conducted usingaDenverD-12flotationmachine(Figure5)equipped witha2-litertankanda3.88-inchdiameterimpeller. Feed slurry of 30% solids by weight was used in all experiments. Natural pH of 7.9 was maintained in all the

Get Quote

Flotation and adsorption of muscovite using mixed cationic ...

Besides dynamic contact angle analysis, AFM and flotation tests were carried out to gain detail information about the wettability of muscovite, adhesion ability of bubbles towards muscovite ...

Get Quote

muscovite flotation flow - kwiaciarnia-lesna.pl

Flotation tests with muscovite were carried out in a 40 mL flotation cell, and the speed of fixed impeller was 1600 rmin. The air flow rate was 0.15 m 3 h. In each flotation test, 2 g of a muscovite sample and 35 mL of deionized water were used. Reagent grade HCl and NaOH were used to adjust the pH. Read More . Synergistic Adsorption and Flotation of New Mixed … Flotation tests with ...

Get Quote

Understanding the effect of mineralogy on muscovite ...

Electroacoustic zeta potential measurements and single mineral flotation tests were used to determine the effect of Custamine 8113 (collector) and Norlig-H (depressant) on muscovite. These results ...

Get Quote

Flotation and adsorption of muscovite using mixed cationic ...

Flotation and adsorption of muscovite using mixed cationic–nonionic surfactants as collector [2015] Wang, Li; Hu, Yuehua; Liu, Jiapeng; Sun, Yongsheng; et al.

Get Quote

Influence of Muscovite Content on the Flotation of Pyrite ...

Muscovite is a hydrophilic, platy micaceous mineral, classified as a phyllosilicate. Previous research identified that micas and clays can have a deleterious effect on the flotation of sulfide minerals; for example, the presence of muscovite is associated with an increase in pulp viscosity, the formation of slime coatings and high recovery of muscovite through entrainment.

Get Quote

Mechanism of separating muscovite and quartz by flotation

investigate the flotation of muscovite and quartz [14−18]. General, muscovite can be recovered using cationic collectors, such as amines. Unfortunately, few of them investigated only one kind of amine. Because of the differences in length of carbon chain and constitute of polar head, amines perform different collector ability and selectivity to muscovite and quartz. There is a wide knowledge ...

Get Quote

Flotation Separation Behavior of Muscovite and Quartz

Pre-separation mainly uses flotation method to separate vein minerals such as vanadium-bearing muscovite and quartz in stone coal. Therefore, dodecylamine, octadecylamine, LU-1 and LU-3 were used as cationic collectors to investigate their flotation effects on muscovite and quartz. The results show that the concentration of collector has a great influence on the flotation of muscovite ...

Get Quote

DEPRESSION EFFECT OF CORN STARCH ON MUSCOVITE MICA AT ...

A series of flotation tests were performed in a 30 cm3 XFG hitch groove type flotation machine with the stirring rate of 1960 rpm. For each test, 2 g sample was added into the flotation cell, and then filled with the solution which pH had been adjusted by sulfuric acid. After stirring 3 min, a certain amount of corn starch solution was added into as the inhibitor of muscovite mica, and then ...

Get Quote

Optimisation of spodumene flotation - 911 Metallurgist

Optimisation of spodumene flotation M. Menéndez*, A. Vidal, J. Toraño, M. Gent Escuela Técnica Superior de Ingenieros de Minas, Universidad de Oviedo C/ Independencia, 13, 33004 Oviedo, Spain Received 10 December 2002; accepted 15 March 2004 ABSTRACT Results of investigations into the optimum conditions for concentration of spodumene by anionic froth flotation are presented. …

Get Quote

IJMMME - Flotation of lithium ores to obtain high-grade ...

Froth flotation tests were conducted in a Leeds open-top laboratory flotation machine with a 3.0 L cell, at an impeller speed of 1000 rpm and an air flow rate of 7.5 L/min. These reported tests were chosen among others, carried out to assess the feasibility of froth flotation to produce Li 2 O concentrates.

Get Quote